企鹅粮油专家讲加工玉米油精炼过程需注意事项
企鹅粮油专家讲加工玉米油精炼过程需注意事项
玉米油加工设备；企鹅粮油专家讲解加工玉米油精炼过程需注意事项
玉米油作为我们一种常用的新式食用油，其在用油脂设备精粹加工过程中，需要留意哪些事项呢?
Corn oil as we are a commonly used new edible oil, the in the use of oil equipment, the essence of the process and need to pay attention to what matters?
对于这个疑问，我们企鹅粮油油脂精粹专家人员将玉米油精粹留意事项为我们共享如下：
For this question, we will be the essence of grain and oil fat Penguin expert of corn oil essence note we share are as follows:
(1)油脂设备精粹脱胶期间对制品油的影响较大。假如脱胶作用欠好，会影响制品玉米油的色泽，胶质含量，进而影响后续的汽提作用。
(1) during the period of oil equipment has great influence on the essence of degumming oil products. If the function of the product is not good, it will affect the color and the content of the corn oil, and then affect the subsequent stripping.
(2)精粹油设备碱练时选用纯度为99%的固体碱片，由于钙镁离子的存在对制品油的色泽也有相应影响。
(2) the essence oil equipment alkali scouring selection of purity is 99% of the solid base, due to the presence of calcium and magnesium ions on oil products color also has a certain influence.
(3)由于玉米原油在压榨浸出设备浸出期间含杂量较高，主张在脱胶碱练前进行静置沉积，下降玉米油中的含杂量，进步别离机的别离作用，将玉米原油中的杂质含量控制在0.2%以下。
(3) because of the high impurity content in the extraction of crude oil in the press, the static and the content of the corn oil were decreased, and the content of impurities in crude oil was controlled at 0.2%.
(4)脱臭期间软塔中油温不宜太高，控制在230度左右。
(4) the deodorization tower during the soft oil temperature should not be too high, at about 230 degrees.
(5)脱臭工段的玉米制品油，要冷却后，才干入库，冬天，入库油温控制在30度以下，夏日，油温控制在35度以下。
(5) stinky section of corn products oil removal, must after cooling, talent storage, winter, storage temperature control in 30 degrees Celsius. In summer, the temperature is controlled below 35 degrees.
(6)为进步玉米制品有的收率，下降生产成本，精粹设备碱练油的酸值0.2—0.25g/mg之间。
(6) for the progress of corn products and some yield, decreased production cost, the essence of equipment between alkali scouring oil acid value is 0.2 0.25g/mg.
(7)为进步脱蜡工段的过滤速率，进步脱蜡作用，助滤剂主张用硅藻土，而不选用珍珠岩。
(7) the filtration rate progressive dewaxing section, progressive dewaxing filter aid effect, advocate the use of diatomite, instead of using the perlite.
Copyright: Zhengzhou QIE Oil Machinery Co., Ltd.
